连续制板用无碱玻璃纤维短切毡 E-glass Chopped Strand Mat For Continuous plate

连续制板用无碱玻璃纤维短切毡

E-glass Chopped Strand Mat For Continuous plate

连续制板用无碱玻璃纤维短切毡是由连续玻璃纤维原丝经短切后，随机无定向分布，用粘结剂粘结而成的片状毡片。

E-glass Chopped Strand Mat For Continuous plate are an unwoven fabric consisting of randomly distribute chopped strands held together with binder.

可适用于增强不饱和聚酯树脂、乙烯基树脂、环氧树脂等。

短切毡在机械连续制版中，主要用于透明工艺品、洁具、厕板等产品。

Chopped strand mat are compatible with unsaturated polyester vinyl ester and epoxy resins.

E-glass chopped strand mats for continuous plate are are mainly used in Transparent crafts、sanitary appliance、Toilet board and so on.

产品特点Product Features

 1、单位面积质量均匀，保证了制品的玻璃纤维含量和力学稳定性

2、毡片粘结剂分布均匀，保证粘接良好、掉纱少，同时使毡卷直径小

3、毡层的结构设计是毡具有优良的柔韧性，操作时贴模性好，小角度情况不回弹

4、树脂浸穿浸透快且速度一致，易排除气泡，降低树脂耗用和生产成本，同时提高工作效率和最终制品的力学性能。

5、制品干、湿态强度高，并且透明性好

1.Uniform density ensures consistent fiberglass content and mechanical properties of the composites products.

2.Uniform binder distribution ensure good mat intergrity.little loose fibers and small roll diameter.

3.Excellent flexibility ensures good moldability with no springback at sharp angles.

4.Fast and consistent wet-out speed in resins and rapid air release reduce resin consumption and cost and enhance

productivity and mechanical properties of the end products.

5.The composite products have high dry and wet tensile strength and good transparency.

  连续制板用无碱玻璃纤维短切毡

E-glass Chopped Strand Mat For Continuous plate

技术指标Technical Parameters

注：无碱玻璃纤维短切毡产品幅宽范围200mm-3600mm，可根据客户特殊要求和使用习惯提供下同浸   透和分解时间要求的产品。

Note：E-glass chopped Strand Mat For Hand lay-up are available with a width range of 200mm一3600mm.

Other specifications are also available on customer request.                                                                                                                                                                                                                                                                                                                                                                                        

包装及储存说明    Pack8ging＆Storage

连续制板用无碱玻璃纤维短切毡缠绕在内径79mm、99mm或106mm的纸管上，按照产品要求可做成200米/卷、300米/卷.500米/卷，用塑料防潮袋包扎，外用纸箱或牛皮纸包装．垂直或水平放置。

装入集装箱时可散装也可用托盘包装。

   Each chopped strand mat is wound onto a paper tube which has an inside diameter of 79mm，90mm or 106mm，the products can be made in 200m/roll, 300m/roll or 500m/roll according To customer request，wrapped up with plastic film and then be packed in a cardboard box or wrapped up with Kraft paper The rolls can be vertically or horizontally Placed. The rolls can be loaded into a container directly or on pallets

  在没有特殊要求的情况下，手糊工艺用无碱玻璃纤维短切毡储存在干燥凉爽的地方防止雨淋。储存控制温度15℃一35℃-湿度35%-65%。为了确保产品安全、避免损坏产品，托盘的堆码高度不超过两层；无托盘水平放置不超过4层。

Unless otherwise specified.E-glass chopped strand mat should be stored in a dry.coal and rain-proof area .it is commended that the temperature and humidity should be always maintained at 15℃-35 ℃ and35%-65respectively To ensure safety and avoid damage to the product, the pallets should not be stacked more than two layers.

Any package without pallet should not be stacked horizontally more than four layers.