防水用无碱玻璃纤维毡E-glass Light Weight Chopped Strand Mat For waterproofing
防水用无碱玻璃纤维毡是由无色及有色高强度玻璃纤维纱经混合后，无定向均匀分布，然后用特殊型粘结剂粘合在一起而制成的无纺织物。
E-glass chopped strand mats for waterproofing is unwoven fabric which is mixed by colorless and colorful high-strength chopped strands，distributed randomly and held together with special binder.
适用树脂和产品Compatible Resins and Application
可适用于增强不饱和聚酯树脂、乙烯基树脂、环氧树脂等。
防水用无碱玻璃纤维毡，是一种建筑物防水的新型材料，具有优良的机械物理和化学性能，便捷的操作工艺。主要应用于建筑屋面防水，以及厨房、卫生间、露天阳台、楼层间的防渗、防裂、解决了异形建筑结构的防渗、防水处理。
E-glass chopped strand mats for waterproofing are compatible with unsaturated polyester vinyl ester, epoxy resins.
The product as a new type of waterproof building material has perfect physical mechanical character and chemical property and handy operation technics. It is most widely used in water proofing of buildings' surface,anti seepage or crack control in kitchen, bathroom,open balcony and floor-between-floor. It deal with the problem of anti seepage and crack control to structure of buildings.
产品特点Product Features
1、单位面积质量均匀。
2、保证了产品在搭接对厚度均匀和性能稳定。
3、产品的强度和可控性长度确保施工要求。
4、毡层的结构设计使毡具有优良的柔韧性，操作时贴模性好，小角度情况不回弹。
5．树脂浸穿、浸透快且速度一致，不产生气泡，降低树脂耗用和施工成本，提高工作效率和最终制品的力学性能。
1.Uniform density ensures consistent fiberglass content and mechanical properties of the composites products.
2.Ensure the thick uniformity and feature stability when the products are joint together.
3.The strength of the product and the length in controlled ensure the construction requirement.
4.Excellent flexibility ensures good moldability with no springback at sharp angles.
5.Fast and consistent wet-out speed in resins and rapid air release reduce resin consumption and productions cost and enhance productivity and mechanical properties of the end products.
性能Property |
单位面积质量 |
含水率 |
可燃物含量 |
断裂强度 |
幅宽 |
p01 |
380±5% |
≤0.20 |
4.2±0.9 |
≥200 |
±5 |
P01 |
430±5% |
≤0.20 |
4.0±0.8 |
≥220 |
±5 |
p02 |
480±5% |
≤0.20 |
3.8±0.8 |
≥240 |
±5 |
P02 |
500±5% |
≤0.20 |
3.8±0.8 |
≥240 |
±5 |
技术指标Technical Parameters
注：防水用无碱玻璃维粉剂毡产品幅宽范围(200+200)mm-(3400+200)mm，可根据客户特殊要求提供产品。排号说明P01为通用型；P02为特殊型。
Note :The products are available with a width range of(200+200)mm-(3400+200)mm. Other specifications are also available on customer request. Product No.P1 is common type.P2 is special type.
包装说明Packaging
防水用无碱玻璃纤维毡缠绕在内径79mm、90mm域106mm的纸管上，毡卷直径为265mm,甩塑料防潮袋包扎，外用牛皮纸包装，垂直或水平放置，装入集装箱时可散装也可用托盘包装。
Each chopped strand mat is wound onto a paper tube which has an inside diameter of 79mm，90mm and 106mm.
The diameter of the roll is 265mm.The rail is wrapped up with plastic moisture-proof bag and then packed in a cardboard box or wrapped up with Kraft paper. The rolls can be vertically or horizontally placed. Far transportation. the rolls can be loaded into a container or on pallets.
储存说明storage
在没有特殊要求的情况下，防水用无碱玻璃纤维毡储存在干燥凉爽的地方，防止雨淋。建议粗存控制温度15℃-35℃，湿度35%-65%。为确保产品安全、避免损坏产品，托盘的堆码高度1层；建议施工过程存放时全部水平放置，放置高度不超过四层。
Unless otherwise specified，the product should be stored in dry coal and rain-proof area.
it is recommended that the room temperature and humidity should be always maintained at 15℃-35℃.and 35%-65% respectively. To ensure safety and avoid damage to the product，the pallets should not be stacked more than one layers.it is recommended that all packages should be stacked horizontally and no more than four layers in the process of construction.